Product ID:PRIST HI-FLASH ANTI-ICING AVIATION FUEL ADDITIVE
MSDS Date:09/01/1994
FSC:9140
NIIN:00F044551
MSDS Number: BYKMS

Emergency Phone: 412-434-3131

Info Phone: 412-434-3131

Cage: 47695

Telephone: 1-800-245-2974 (CAL HYPO)

Cage: 47695

DIETHYLENE GLYCOL METHYL ETHER, 2-(2-METHOXYETHOXY) ETHANOL

CAS: 111-77-3

RTECS: KL6125000

Fraction By Weight: >99%

LD50 LC50 Mixture:ORAL LD50(RAT): 5.5 GM/KG (UNDILUTED)
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: SLIGHTLY TOXIC. EYE &
MUCOUS MEMBRANE IRRITANT. A NEPHROTOXIN & CNS DEPRESSANT.
EYES/SKIN: MILD TO MODERATE IRRITATION. INGESTION: SLIGHTLY TOXIC.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, PAIN & TRANSIENT INJURY.

First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED.
EYES: FLUSH W/PLENTY OF WATER FOR 15 MINS. SKIN: WASH W/SOAP &
WATER FOR 15 MINS. INGESTION: IF CONSCIOUS: DRINK LARGE QUANTITIES
OF WATER. THEN INDUCE VOMITING BY PLACING FINGER FAR BACK IN
THROAT. IF VOMITING CAN'T BE INDUCED, TAKE IMMEDIATELY TO
HOSPITAL/PHYSICIAN. IF UNCONSCIOUS/CONVULSIONS: TAKE IMMEDIATELY TO
HOSPITAL. (SEE SUPP)

Flash Point Method:TCC
Flash Point:192F
Lower Limits:1.2
Upper Limits:22
Extinguishing Media:WATER, DRY CHEMICALS, CO2, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA.
KEEP PERSONNEL REMOVED & UPWIND.
Unusual Fire/Explosion Hazard:NONE

Spill Release Procedures:IMMEDIATELY EVACUATE & PROVIDE MAXIMUM
VENTILATION. UNPROTECTED PERSONAL SHOULD MOVE UPWIND. DIKE TO
CONTAIN. PREVENT CONTAMINATION OF GROUND & SURFACE WATERS. RECOVER
MATERIAL ON ABSORBENTS & SWEEP I NTO CLOSED CONTAINERS FOR
DISPOSAL. (SEE SUPP)

Handling and Storage Precautions:FOR USE ONLY AS AN ANTI-ICING AGENT IN
HIGH FLASH JET FUEL ONLY. STORE ONLY IN CLOSED, PROPERLY LABELED
CONTAINERS. KEEP AWAY FROM HEAT/SPARKS & FLAME
Other Precautions:USE PROPER PROPORTIONING EQUIPMENT TO BLEND INTO
FUEL. KEEP OUT OF REACH OF CHILDREN. AVOID CONTACT W/SKIN & EYES.
DON'T SWALLOW, INHALE.

Respiratory Protection:USE A HALF/FULL FACEPIECE ORGANIC VAPOR CHEMICAL
CARTRIDGE/CANISTER RESPIRATOR WHEN PERMISSABLE LIMITS ARE EXCEEDED.
USE SCBA/FULL FACEPIECE AIRLINE RESPIRATOR W/AUXILIARY SCBA
OPERATED IN PRESSURE DE MAND MODE FOR EMERGENCIES.
Ventilation:USE LOCAL EXHAUST/DILUTION VENTILATION.
Protective Gloves:IMPERVIOUS, CHEMICAL RESISTANT
Eye Protection:SPLASHPROOF GOGGLES
Other Protective Equipment:BOOTS/APRONS/CHEMICAL SUITS/PROTECTIVE
CLOTHING/BUTYL RUBBER.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. DON'T EAT, DRINK/SMOKE IN WORK AREA.
Supplemental Safety and Health
FIRST AID CONT'D: DON'T INDUCE VOMITING/GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. NOTE TO PHYSICIAN: TREAT SYMPTOMATICALLY.
OBTAIN MEDICAL ATTENTION IN ALL CASES. SPILLS CONT'D: AFTER VISIBLE
T RACES, INCLUDING IGNITABLE VAPORS, HAVEBEEN REMOVED THOROUGHLY
WET VACCUM THE AREA. DON'T FLUSH TO SEWER.

Boiling Pt:B.P. Text:379F
Melt/Freeze Pt:M.P/F.P Text:-121F
Vapor Pres:0.2
Vapor Density:4.1
Spec Gravity:1.023
pH:7-8
Evaporation Rate & Reference:(BU AC =1): 0.1
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, COLORLESS LIQUID W/MILD PLEASANT ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
CONTAMINATION W/ALKALI AT ELEVATED TEMP.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CO, CO2

Waste Disposal Methods:USE CARE WHEN DISPOSING OF CHEMICAL MATERIAL &
THEIR CONTAINERS TO PREVENT ENVIRONMENTAL CONTAMINATION. DISPOSE OF
THE CHEMICAL IAW/CLEAN AIR ACT, CLEAN WATER ACT & IAW/FEDERAL,
STATE & LOCAL REGULATI ONS. COMBUSTIBLE LIQUID NA1993. AEROSOLS:
UN1950.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.